Vanguard SDVBP(A) Instrukcja Instalacji

CAST IRON STOVE AND DIRECT-VENT(FREESTANDING FIREPLACE HEATER)BURNER SYSTEM®OWNER’S OPERATION AND INSTALLATION MANUALNATURAL GAS BURNER SYSTEM MODEL S

10®CAST IRON STOVE AND BURNER SYSTEM105499SDVBN(A) AND SDVBP(A) WARNING: Read all instruc-tions completely and thoroughlybefore attempting installatio

11105499OWNER’S MANUALINSTALLATION FORHORIZONTAL TERMINATION1. Determine the route your horizontalventing will take. Note: The locationof the horizont

12®CAST IRON STOVE AND BURNER SYSTEM105499SDVBN(A) AND SDVBP(A)UPVENTINGINSTALLATIONContinued(FramingDetail)10"(254mm)10"(254mm)7 1/2"(

13105499OWNER’S MANUALVENTINGINSTALLATIONContinuedFigure 26 - Horizontal TerminationConfiguration for Rigid VentingFigure 27 - Horizontal Termination

14®CAST IRON STOVE AND BURNER SYSTEM105499SDVBN(A) AND SDVBP(A)Flat Ceiling Installation1. Cut a 10" square hole in the ceiling us-ing the locati

15105499OWNER’S MANUALVENTINGINSTALLATIONContinuedFigure 31 - Installing FirestopIf area above is not a room, installfirestop below framed hole.If are

16®CAST IRON STOVE AND BURNER SYSTEM105499SDVBN(A) AND SDVBP(A)Venting with Two 90° ElbowsVertical (V1) Horizontal (H)5' min. 6' max.6'

17105499OWNER’S MANUALFigure 37 - Vertical Rigid VentingConfiguration With No Horizontal RunVENTINGINSTALLATIONContinuedVertical VentingV = 40' m

18®CAST IRON STOVE AND BURNER SYSTEM105499SDVBN(A) AND SDVBP(A)Figure 39 - Gas Connection* The A.G.A. design-certified manual shutoff valve may be sup

19105499OWNER’S MANUALPressure Testing Gas SupplyPiping SystemTest Pressures In Excess Of 1/2 PSIG(3.5 kPa)1.Disconnect burner system and itsindividua

2®CAST IRON STOVE AND BURNER SYSTEM105499SDVBN(A) AND SDVBP(A)SAFETYINFORMATION1. This appliance is only for use with thetype of gas indicated on the

20®CAST IRON STOVE AND BURNER SYSTEM105499SDVBN(A) AND SDVBP(A)STOVE ANDDIRECT-VENTBURNER SYSTEMINSTALLATIONContinuedTest Pressures Equal To or Less T

21105499OWNER’S MANUALSTOVE ANDDIRECT-VENTBURNER SYSTEMINSTALLATIONContinuedINSTALLING OPTIONALWALL MOUNTEDTHERMOSTAT - GWMT1 WARNING: Installation mu

22®CAST IRON STOVE AND BURNER SYSTEM105499SDVBN(A) AND SDVBP(A)REMOVING/REPLACINGGLASS DOOR CAUTION: Do not operate thisburner system with a brokengla

23105499OWNER’S MANUALEach log is marked with a number. Thesenumbers will help you identify the log wheninstalling. It is very important to installthe

24®CAST IRON STOVE AND BURNER SYSTEM105499SDVBN(A) AND SDVBP(A)TO TURN OFF GASTO APPLIANCE1. Open lower louver panel.2a. Turn ON/OFF switch to “OFF”.2

25105499OWNER’S MANUAL1. After lighting, let pilot flame burn forabout one minute. Turn gas controlknob on the control valve to ON posi-tion. Turn var

26®CAST IRON STOVE AND BURNER SYSTEM105499SDVBN(A) AND SDVBP(A)INSPECTINGBURNERSCheck pilot flame pattern and burner flamepatterns often.PILOT ASSEMBL

27105499OWNER’S MANUALCLEANING ANDMAINTENANCE WARNING: Turn off burnersystem and let cool beforecleaning. CAUTION: You must keepcontrol areas, burners

28®CAST IRON STOVE AND BURNER SYSTEM105499SDVBN(A) AND SDVBP(A)TROUBLESHOOTINGNote: All troubleshooting items are listed inorder of operation. WARNIN

29105499OWNER’S MANUALOBSERVED PROBLEMBurner does not light after pilot is litDelayed ignition burnerBurner backfiring during combustionSlight smoke o

3105499OWNER’S MANUALPILOTLOHIOFFONONOFFAUTOPRODUCTIDENTIFICATIONInstall and use stove and burner system withcare. Follow all local codes. In the abse

30®CAST IRON STOVE AND BURNER SYSTEM105499SDVBN(A) AND SDVBP(A)TROUBLESHOOTINGContinued WARNING: If you smell gas• Shut off gas supply.• Do not try to

31105499OWNER’S MANUALSERVICE HINTSWhen Gas Pressure Is Too Low• pilot will not stay lit• burners will have delayed ignition• burner system will not p

32®CAST IRON STOVE AND BURNER SYSTEM105499SDVBN(A) AND SDVBP(A)SPECIFICATIONSSDVBN(A) SDVBP(A)16,000-22,000 Btu/h 14,000-20,000 Btu/hGas Type Natural

33105499OWNER’S MANUALACCESSORIESPurchase these stove and burner systemaccessories from your local dealer. If theycan not supply these accessories, ca

34®CAST IRON STOVE AND BURNER SYSTEM105499SDVBN(A) AND SDVBP(A)ILLUSTRATEDPARTSBREAKDOWNSDVBN(A)SDVBP(A)LOHIPILOTOFFON24271920212326-126-426-226-32930

35105499OWNER’S MANUALKEYNO. PART NUMBER DESCRIPTION QTY.1 105478-01BR Firebox Assembly 12 M11084-26 Screw, Hex 23 105482-01CK Rear Cover 14 M11084-39

36®CAST IRON STOVE AND BURNER SYSTEM105499SDVBN(A) AND SDVBP(A)ILLUSTRATEDPARTSBREAKDOWNAMITY™SCIVF(*) SERIESPSCIVF(*) SERIES(* Indicates Color Suffix

37105499OWNER’S MANUALPARTS LISTAMITY™SCIVF(*) SERIESPSCIVF(*) SERIES(* Indicates Color Suffix Designation)This list contains replaceable parts used i

VANGUARD LIMITED WARRANTYDIRECT-VENT BURNER SYSTEM AND AMITY™ STOVE CHASSISDESA International warrants this product to be free from defects in materia

4®CAST IRON STOVE AND BURNER SYSTEM105499SDVBN(A) AND SDVBP(A)LOCATION AND SPACEREQUIREMENTSDetermine the safest and most efficient loca-tion for your

5105499OWNER’S MANUALPalletWoodBolted toBottom ofStoveBodySTOVE BODY ASSEMBLY1. Lift off corrugated box enclosing stovebody crating.2. Remove all scre

6®CAST IRON STOVE AND BURNER SYSTEM105499SDVBN(A) AND SDVBP(A)CAST IRON STOVEAND DIRECT-VENTBURNER SYSTEMASSEMBLYContinuedFigure 12 - Attaching Stove

7105499OWNER’S MANUAL WARNING: Never touch theblower wheel while in operation.7. Peel off the backing paper and stick thesupplied wiring diagram decal

8®CAST IRON STOVE AND BURNER SYSTEM105499SDVBN(A) AND SDVBP(A)LOCATION OF VENTTERMINATIONWhen locating vent termination, it is impor-tant to observe t

9105499OWNER’S MANUALFixedClosedOpenableFixedClosedOpenableVVVVVVVVXXVXGGJFBBKNHIANELDBMACBVVAGGBTERMINATION CAPAIR SUPPLY INLETGAS METER RESTRICTED A